READ DESCRIPTION - IMPORTANT INFORMATION

How To Change Transmission Fluid / Oil In Citroen DS5

The Aisin Tf-80 is used in a variety of vehicles, some of which are listed below. The method will be very similar if not identical.
Citroen: DS3, DS4, C4, C5, C6
Peugeot: 307, 308, 407, 408, 508, 607, 3008, 5008
Full List Of Other Brands At Bottom Of Description Box, they include Volvo, VW, Toyota, Mazda and others.

This is for the Aisin BVA AM6C type transmission. Please check which transmission you have. It may or may not be similar. The computer Diagbox steps shown in the video aren't a strict requirement, but they will ensure the best improvement in the gearbox after service.

Part Numbers:
O-Ring, PSA: 220945 , GM: 93183574
Crush Washer, PSA: 220923 , GM: 93183578

CAUTION : The oil type "AW-1" in AT6 and AM6 gearboxes with engine version Euro 5 is specific and cannot be replaced with oil type "JWS 3309".

Dry gearbox oil capacity : Approximately 7 litres.

Type of oil required (Red) :
EURO 5 engine : AW-1 oil
EURO 4 engine : JWS 3309 ESSO oil
Volume of oil remaining after draining : Approximately 4 litres.
Quantity of oil to be replaced : Approximately 3 litres.

5. To Check the oil level
Prior conditions :
Vehicle level
Check that the gearbox is not in downgrade mode
Remove the filler plug (3)
Add 0.5 additional litres of oil in the gearbox
Apply the brakes firmly and move the lever through the various selector positions
Gear lever in position "P"
Engine running at idle
Oil temperature 60°C (+ 8 ; - 2 °C) (Measurement of the parameters using diagnostic equipment)
Remove the oil level plug (2).

5.1. Stream of oil then reducing to a sequence of drips
Refit the oil level plug (2).

5.2. Sequence of drips or nothing
Refit the oil level plug (2).
Stop the engine.
Add 0.5 additional litres of oil in the gearbox.
Repeat the top-up procedure.
N.B. : The level of oil is correct when the stream of oil becomes drop by drop.
Refit the oil level plug (2) (equipped with a new seal).

5.3. Check the oil level (continued)
Refit :
The oil filler plug (3) (equipped with a new seal)
The protective panel under the engine
The air filter housing
Too high a fluid level can cause :
Overheating of the fluid
Fluid leaks
Too low a level causes destruction of the gearbox.

FULL LIST OF VEHICLES WITH THIS TRANSMISSION BELOW:
The Fluid change procedure should be very similar across all, but I take no responsibility for differences. Check Yourself!

BMW/MINI
2014-2020 i8
2015–present 225xe Active Tourer (F45)
2020–present X1 xDrive 25e (F48)
2020–present X2 xDrive 25e (F39)
2014-2017 (F56/55)
2015-2017 Clubman (F54) with 3 cylinder engines (B37 and B38)
2016-2017 Countryman (F60) with 3 cylinder engines (B37 and B38 FWD)

Alfa Romeo
2005–2011 159
2005–2010 Brera
2006–2010 Spider

Fiat
2005–2011 Croma
2012–2019 500

Lancia
2008–2014 Delta

Ford
2005–2007 Five Hundred
2006–2012 Fusion (US)
2007–2014 Mondeo MkIV 2.3 160 PS Petrol and 2.0 TDCi Diesel
2006–2014 Galaxy 2.3 118kw / 160PS Petrol (as standard gearbox)

Lincoln
2006 Zephyr
2007–2012 MKZ

Mercury
2005–2010 Milan
2005–2007 Montego

Cadillac
2005–2010 BLS
2009–2016 SRX II

Chevrolet
2008–2016 Cruze

Opel / Vauxhall
Astra
Vectra
Signum
Zafira
2008–2017 Insignia
2014–2017 Meriva

Saab
2006–2014 9-3 II (FWD & AWD)
2013–2014 9-3 III
2010–2012 9-5 II

Hyundai
2006–2014 Veracruz

Jaguar
2007–2009 X-type

Land Rover
2006–2014 Freelander 2
2011–2013 Range Rover Evoque

Mazda
2005–2008 6 I
2006–2012 CX-7
2006–present CX-9
2006–present MPV III
2007–2012 6 II

Citroën
C4
C5
C6
C8
DS3
DS4
DS5
2010–2016 Jumpy
C-Elysée

Peugeot
2006–2008 307
2014-2018 308
2005–2010 407
2010–present 408
2011–2018 508
2005–2010 607
2008– 3008
2009– 5008
2010–2016 Expert

Renault
2005-2009 Vel Satis
2006-2010 Espace

Suzuki
2014–present Vitara (FWD & AWD)
2015–present Baleno
2017–present Swift
2017–present SX4 S-Cross

Toyota
2006–2008 Previa (V6)
2007–2018 Camry
2007–2017 Aurion (V6)
2007–2012 Blade (V6)
2007–2013 Mark X Zio (V6)
2008–2016 Highlander
2008–2017 Alphard (V6)
2008–2018 Avalon
2008–2018 RAV4
2009–2017 Venza
2011–2016 Sienna
2017 ProAce

Lexus
2007–2018 ES350
2010–present RX (350 older models, 200t/300 new models)
2015–present NX200t (300 2018–present)

Lotus
2012 Evora (IPS)
2022–Emira (V6)

Scion
2011–2016 tC

Audi
2003–2013 A3
2015–2018 Q3

Škoda
Octavia
Rapid (India, 2019 improvement)

Volkswagen
2003–2010 Transporter
2007 Jetta
2009–2017 Tiguan
2012–present Passat (NMS)
2019–present Polo (MK5) (India)

Volvo
2005–2014 XC90 (FWD & AWD)
2006–2009 S60 (FWD & AWD)
2006–2008 V70 II (FWD & AWD)
2006–2008 XC70 (AWD)
2007–2016 S80 II (FWD & AWD)
2008–2016 V70 III (FWD & AWD)
2008–2016 XC70 II (FWD & AWD)
2009–2017 XC60 (FWD & AWD)
2011–2018 S60 II (FWD & AWD)
2016-2017 S90 (FWD)
2011–2018 V60 (FWD & AWD)
2011–2012 S40 II (FWD)
2011–2012 V50 (FWD)
2011–2013 C30 (FWD)
2011–2013 C70 II (FWD)
2012–2014 V40 II (FWD)